All Purpose Hospital Grade

Safety Data Sheet

Issue Date 10-17-2018

Revision Date 03-01-2020

Version 3

IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND THE COMPANY
1.1. Product identifier
Product name BIOGLOVE – PBG HOSPITAL GRADE DISINFECRANT
Product number PBG-AP
UN/ID No NA
Product Code Smart Green PBG-AP
1.2. Relevant identified uses of the substance or mixture and uses advised against
Recommended Use: Hard Surface Disinfectant hospital grade.
1.3. Details of the supplier of the safety data sheet Supplier Address::

BioGlove / SmartGreen
30 Gould ST.
Sheridan WY 82801

1.4. Emergency telephone number dial 911
Non-Emergency dial 877-BioGlove (246-4568)
COMPOSITIONS/INFORMATION ON INGREDIENTS
3.2. Mixtures CAS #
Demineralized Water 7732-18-5 >87.5 %
2-Propanol 67-63-0 >5.0 %
Polyhexamethylene biguanide hcl 32289-58-0 0.01- 0.5 %
1-Octadecanamimium N,N
dimethyl 3- trimethoxysilyl propyl chloride 27668-52-6 >1.50 %
Alkyl(C14-50%, C12-40%, C16-10%) Dimethyl
Benzyl ammonium chloride 68424-85-1 >0.45 %
Octadecyldimethyl ammonium chloride 32426-11-2 >0.40 %
Dioctyldimethyl ammonium chloride 5538-94-3 >0.40 %
Didecyldimethyl ammonium chloride 7173-51-5 >0.20 %
Ethylene glycol monophenol ether 122-99-6 0.25-0.75 %
Polyethylene Tridecyl ether 24938-91-8 0.25-0.75 %
Ethanol 64-17-5 >0.01 %
Laurylamine 124-22-1 >0.01 %
EDTA Sodium salt 13235-36-4 0.25-0.75 %
Citric acid 77-92-9 >0.001 %
FIREFIGHTING MEASURES
5.1. Extinguishing media

Extinguishing media
Extinguish with foam, carbon dioxide, dry powder or water fog.

5.2. Special hazards arising from the substance or mixture

Specific hazards
None.

5.3. Advice for firefighters

Protective equipment for fire-fighters
Self-contained breathing apparatus and full protective clothing must be worn in case of fire.

STORAGE AND HANDLING
Advise on safe handling: Avoid contact with skin and eyes.
Provide sufficient air exchange and/ or exhaust in work rooms
Conduct for safe storage: Keep container tightly closed
Recommended storage temperature: 18.3-35C above 32F Do not freeze
PHYSICAL AND CHEMICAL PROPERTIES
9.1. Information on basic physical and chemical properties
Physical state Category 3 Liquid
Appearance Clear to cloudy (when cold)
Odor Sweet
Odor Threshold Not determined
pH 3.5-7.0
Melting point/freezing point 0°C/0°C
Physical state Category 3 Liquid
Boiling point/boiling range NA °C
Flash point close cup 49.6 °C
Evaporation rate NA
Flammability (solid, gas) N/A
Flammability Limits in Air
Upper flammability limits N/A
Lower flammability limit N/A
Vapor pressure TBD mmHg
Vapor density TBD gm/m³
Specific Gravity @ 23.5C 0.95-1.02
Water solubility Soluble in water
Solubility in other solvents Not determined
Partition coefficient Not determined
Autoignition temperature Not determined
Decomposition temperature Not determined
Other Information
TOXICOLOGICAL INFORMATION
11.1. Information on toxicological effects

Acute Oral LD50
LD50>2000mg/kg <5000mg/kg Category 5
Acute Dermal LD50
Ld50>2000mg/kg <5000mg/kg
Skin contact
Non-irritant.
Acute Eye Irritation
Reversible eye irritation Category 2B
Acute Inhalation Toxicity
LC50 <4.8mg/L Category 4
Skin Sensitization contact
Non-sensitization
Germ Cell Mutagenicity

Data is not available at this time

Carcinogenicity

Data is not available at this time. Not expected to be carcinogenic.

Reproductive Toxicity

Data is not available at this time. Not expected to have reproductive toxicity.

STOT-single exposure

Unclassified

STOT-repeated exposure

Unclassified

Aspiration Hazard

Data is not available at this time

DISPOSAL CONSIDERATIONS
General information

Factory Waste to be treated as controlled waste. Disposal to licensed waste disposal site in accordance with local Waste Disposal Authority. Do not puncture or incinerate even when empty This Disinfectant is slightly toxic to fish. Do not discharge effluent containing this product into lakes, streams, ponds, estuaries, oceans, or other waters unless in accordance with the requirements of a National Pollutant Discharge Elimination System (NPDES) permit and the permitting authority has been notified in writing prior to discharge. Do not discharge effluent containing this product to sewer systems without previously notifying the local sewage treatment plant authority. For guidance,contact your State Water Board or Regional Office of the EPA..

13.1. Waste treatment methods

Dispose of waste and residues in accordance with local authority require

REGULATORY INFORMATION
15.1. Safety, health and environmental regulations/legislation specific for the substance or Mixture
International Inventories
TSCA Listed
DSL Listed
NDSL NOT Listed
EINECS Listed
ELINCS NOT Listed
ENCS
IECSC
KECL
PICCS
AICS
Legend:

TSCA – United States Toxic Substances Control Act Section 8(b) Inventory
DSL/NDSL – Canadian Domestic Substances List/Non-Domestic Substances List
EINECS/ELINCS –European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances
ENCS – Japan Existing and New Chemical Substances
IECSC – China Inventory of Existing Chemical Substances
KECL – Korean Existing and Evaluated Chemical Substances
PICCS – Philippines Inventory of Chemicals and Chemical Substances

US Federal Regulations SARA 313

Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 37.

SARA 311/312 Hazard Categories
Acute health hazard NO
Chronic Health Hazard NO
Fire Hazard NO
Sudden release of pressure hazard NO
Reactive Hazard NO
CERCLA
Chemical Name Hazardous Substances RQs CERCLA/SARA RQ Reportable Quantity (RQ)
Not Listed
US State Regulations

U.S. State Right-to-Know Regulations

Chemical Name New Jersey Massachusetts Pennsylvania
Not Listed Not Listed Not Listed Not Listed

U.S. EPA Label Information

HAZARDS IDENTIFICATION
2.1. Classification of the substance or mixture
US Hazard Classification (29CFR 1910.1200-2012):
PFlammable Liquid and Vapor: Category 3 H226
Acute Toxicity-Oral: Category III H302
Acute Toxicity-Dermal: Category III H313
Acute Toxicity- Air Inhalation: Category IV H332
Acute Toxicity-Skin Corrosion/Irritation Non-irritant
Acute Toxicity-Serious Eye Damage/Irritation: Category III H320
Acute Toxicity-Skin/Dermal Sensitization: Non-irritant
GHS Hazard Classification

Acute Toxicity-Oral: Category 5
Acute Toxicity-Dermal: Category 5
Acute Toxicity-Air Inhalation: Category 4
Acute Toxicity-Skin Corrosion/Irritation: Non-irritant
Acute Toxicity-Serious Eye Damage/Irritation: Category 2B
Acute Toxicity-Skin/Dermal Sensitization: Non-sensitization

2.2. Hazard Pictograms

Signal Word: WARNING!

Hazard Statements
H226 Flammable liquid and vapor
H302 May be harmful if swallowed
H313 May be harmful if in contact with skin
H320 Causes eye irritation
H332 Harmful if inhaled
Precautionary Statements
P210 Keep away from heat/sparks/open flames/hot surfaces. No smoking
P233 Keep container tightly closed
P235 Keep cool
P240 Ground/bond container and receiving equipment
P241 Use explosion proof electrical/ventilation/lighting
P242 Use only non-sparking tools
P243 Take precaution measures against static discharge
P260 Do not breathe dust/fume/gas/mist/vapors/spray.
P261 Do not eat, drink or smoke when using this product
P264 Wash hands thoroughly after handling
P280 Wear protective gloves/protective clothing/eye protection/face protection
P301 Call a Poison Center or doctor/ physician if you feel unwell
P303 IF ON SKIN (or hair): Take off immediately contaminated clothing. Rinse skin with water/shower
P312 Call a Poison Center or doctor/ physician if you feel unwell
P330 Rinse mouth.
P303+P361+P353 IF ON SKIN (or hair): Take off immediately contaminated clothing. Rinse skin with water/shower
P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing
P337+P313 If eye irritation persists: Get medical advice or attention
P405 Store locked up
P501 Dispose of contents/container in accordance with all federal, provincial,
and/or local regulations including the Canadian Environmental Protection
Act.
Prevention: Wear protective eyewear (goggles, face shield or safety glasses)
Response: Wash hands before eating, drinking, chewing gum, using tobacco or using the toilet.
Remove contaminated clothing and wash clothing before reuse
2.3. Other hazards
FIRST AID MEASURES
4.1. Description of first aid measures

Inhalation

  • Remove victim immediately from source of exposure. Move person to fresh air.
  • If person is not breathing, call 911 or an ambulance, then give artificial respiration, preferably mouth-to-mouth, if possible.
  • Call a poison control center or doctor for further treatment advice

Ingestion

  • Call a poison control center or doctor immediately for treatment advice.
  • Have person sip a glass of water if able to swallow.
  • Do not induce vomiting unless told to do so by a poison control center or doctor.
  • Do not give anything by mouth to an unconscious person.

Skin contact

  • Take off contaminated clothing.
  • Rinse skin immediately with plenty of water for 15-20 minutes.
  • Call a poison control center ordoctor for treatment advice

Eye contact

  • Immediately flush with plenty of water for up to 15 minutes.
  • Hold eye open and rinse slowly and gently with water for 15-20 minutes.
  • Remove contact lenses, if present, after the first 5 minutes, then continue rinsing.
  • Call poison control center or doctor for treatment advice.
4.2. Most important symptoms and effects, both acute and delayed
4.3. Indication of any immediate medical attention and special treatment needed.
ACCIDENTAL RELEASE MEASURES
6.1. Personal precautions, protective equipment and emergency procedures

Follow precautions for safe handling described in this safety data sheet.

6.2. Environmental precautions

This Disinfectant is slightly toxic to fish. Do not discharge effluent containing this product into lakes, streams, ponds, estuaries, oceans, or other waters unless in accordance with the requirements of a National Pollutant Discharge Elimination System (NPDES) permit and the permitting authority has been notified in writing prior to discharge. Do not discharge effluent containing this product to sewer systems without previously notifying the local sewage treatment plant authority. For guidance, contact your State Water Board or Regional Office of the EPA

6.3. Methods and material for containment and cleaning up

Absorb with inert, damp, non-combustible material, then flush area with water. Collect spillage in containers, seal securely and deliver for disposal according to local regulations.

6.4. Reference to other sections
EXPOSURE CONTROLS/PERSONAL PROTECTION
8.1. Control parameters Ingredient Comments

No exposure limits noted for ingredient(s)

8.2. Exposure controls
Protective equipment

Engineering measures
Provide adequate ventilation. Observe Occupational Exposure Limits and minimize the risk of inhalation of
vapors.
Respiratory equipment
None.
Hand protection
Gloves
Eye protection
Eye glasses with safety shields
Other Protection
Wear appropriate long sleeve clothing.
Hygiene measures
No specific hygiene procedures noted, but good personal hygiene practices are always advisable,
especially when working with chemicals.

STABILITY AND REACTIVITY
10.1. Reactivity

No specific reactivity hazards associated with this product.

10.2. Chemical stability

Stable under normal temperature conditions and recommended use.

10.3. Possibility of hazardous reactions

Not available.

10.4. Conditions to avoid

Avoid excessive heat for prolonged periods of time. Avoid freezing since water based. (will thaw)

10.5. Incompatible materials

Not available

10.6. Hazardous decomposition product

None.

ECOLOGICAL INFORMATION

Ecotoxicity

12.1. Toxicity

Acute Toxicity Daphnia magna OECD 202 Immobility
Data is not available at this time

Acute Toxicity Danio Rerio OECD 203
Data is not available at this time

Fresh water Algae Growth Desmodesmus subspicatus at 72 hours OECD 201
Data is not available at this time

12.2. Persistence and degradability

Degradability
Data is not available at this time

12.3. Bioaccumulative potential

Bioaccumulative potential
Data is not available at this time

12.4. Mobility in soil

Mobility: Data is not available at this time

12.5. Results of PBT and vPvB assessment

This product does not contain any PBT or vPvB substances

12.6. Other adverse effects

Not applicable.

TRANSPORTATION INFORMATION
DOT
Proper shipping name Combustible liquid, n.o.s. contains Isopropyl alcohol
UN/ID No NA1993
Hazard Class Combustible liquid
Packing Group III
Special Provisions Exemption 173.150
TDG
UN/ID No
Proper shipping name
Hazard Class
Packing Group
Special Provisions
IATA
UN/ID No
Proper shipping name
Hazard Class
Subsidiary hazard class
Packing Group
ERG Code
IMDG
UN/ID No
Proper shipping name
Hazard Class
Subsidiary hazard class
Packing Group III
OTHER INFORMATION
GHS Codes
Hazard Statements In Full
USA National Fire Prevention and OSHA
NFPA
Health hazards 2
Flammability 2
Instability 0
Special Hazards
HMIS
Health hazards
Flammability
Physical hazards

Issue Date October 17, 2017

Revision Date March 1, 2020

Revision Note Data Data on physical properties

Disclaimer

The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, this product is manufactured by smart green pbg exclusively for bioglove holdings unless specified in the text.